本文關鍵詞： 半導體激光泵浦固體激光器 脈沖電流源 級聯疊加 線性調節　出處：《燕山大學》2015年碩士論文　論文類型：學位論文

【摘要】：隨著激光產業的發展,半導體激光泵浦固體激光器(Diodes Pumped Solid-State Laser,簡稱DPSSL)在各行各業中的應用愈來愈廣泛,同時對作為激光器重要組成部分的激光電源也提出了更高的要求。由于半導體激光器是一種電流敏感器件,因此激光電源的核心技術是高質量大功率脈沖電流源的實現。本文針對DPSSL驅動源技術展開研究,要求驅動電流波形是近似矩形波的脈沖串,每個脈沖頂部都要求具有一定的平穩度,脈沖的上升沿和下降沿盡量在短時間內完成。首先,通過介紹半導體激光器的工作原理,提出了對驅動電源的設計要求。針對本文脈沖激光電源輸出電壓高、脈沖電流大的特殊驅動要求,最終選擇多模塊級聯疊加形式的放電拓?fù)?并在此拓?fù)涞幕A(chǔ)上研究了一種新穎的控制方案,即對功率開關管實行線性區調節,在實現輸出驅動電流頂部平滑的同時,突破了當前驅動電源所受到的輸出電壓等級限制。其次,對方案中的脈沖電流源電路進行了工作原理的分析,并對該方案中級聯模塊的協調控制、電流閉環反饋調節器的設計及功率開關管類型選取等關鍵問題進行詳細討論。基于脈沖電流的動態、靜態調節要求,采用模擬電路搭建PID電流調節器。采用DSP數字控制產生具有線性上升沿的脈沖電流給定信號,與其輸出的PWM驅動信號協調控制多模塊的工作。此外,在DPSSL驅動電源的多模塊隔離供電方面,專門設計了一臺基于LCC諧振的高頻軟開關DC/DC變換器,作為多儲能電容的充電單元。該變換器具有抗負載開路和短路的特性,滿足脈沖放電負載對能量供給的要求。變換器的閉環環路由同一片DSP芯片實現數字控制,更易于實現輸出電壓的調節功能。最后,通過一個260V/40A的小功率實驗對所提出的級聯型驅動電流控制方案進行驗證,實驗結果證明了此方案的可行性。
[Abstract]:With the development of laser industry, Diodes Pumped Solid-State Laser (DPSSLL) is more and more widely used in various industries. At the same time, the laser power supply, which is an important part of the laser, is also required. Because the semiconductor laser is a kind of current-sensitive device, Therefore, the core technology of laser power supply is the realization of high quality and high power pulse current source. The top of each pulse must have a certain degree of smoothness, and the rising and descending edges of the pulse should be completed in as short a time as possible. First, by introducing the working principle of the semiconductor laser, The design requirements of the driving power supply are put forward. In view of the special driving requirements of the pulse laser power supply with high output voltage and large pulse current, the discharge topology of the cascade superposition of the multi-module is chosen finally. On the basis of this topology, a novel control scheme is studied, that is, the linear regulation of the power switching tube is carried out, and the top of the output drive current is smooth at the same time. It breaks through the limit of the output voltage level of the current driving power supply. Secondly, the working principle of the pulse current source circuit in the scheme is analyzed, and the coordinated control of the cascade module in the scheme is given. The design of current closed-loop feedback regulator and the selection of power switch type are discussed in detail. The PID current regulator is constructed by using analog circuit. The pulse current given signal with linear rise edge is generated by DSP digital control, and the multi-module is coordinated with the output PWM drive signal. A high frequency soft-switching DC/DC converter based on LCC resonance is designed as a charging unit of multi-energy storage capacitors in the multi-module isolated power supply of DPSSL drive power supply. The converter has the characteristics of anti-load open circuit and short circuit. The closed loop of the converter is digitally controlled by the same DSP chip, which makes it easier to adjust the output voltage. The proposed cascade drive current control scheme is verified by a 260V / 40A low-power experiment. The experimental results show that the proposed scheme is feasible.
【學位授予單位】：燕山大學
【學位級別】：碩士
【學位授予年份】：2015
【分類號】：TM46;TN248

【參考文獻】

相關期刊論文 前3條

1 戚棟;王寧會;;一種級聯型結構的固體開關式高壓脈沖電源的研制[J];電子器件;2006年04期

2 邱華學;;三種簡單可靠的大電流恒流源電路[J];電子與自動化;1996年03期

3 黃裕年;;高功率半導體二極管陣列激光器[J];激光技術;1993年06期

相關碩士學位論文 前2條

1 宋傳磊;半導體激光器驅動電源及其調控[D];哈爾濱工業大學;2006年

2 張吙文;新型半導體激光器電源的研制[D];電子科技大學;2010年

，

本文編號：1521625