本文選題：SBS改性瀝青 + 紫外線光老化　； 參考：《武漢工程大學》2014年碩士論文

【摘要】：SBS改性瀝青曝露在高溫和紫外輻射中會發生熱氧老化和紫外老化,均會導致SBS改性瀝青的路用性能和使用壽命下降。研究SBS改性瀝青的熱氧老化和紫外老化對于改善SBS改性瀝青路用性能十分重要,目前已有很多SBS改性瀝青熱氧老化和紫外老化的相關研究,這些研究大多是針對SBS改性瀝青整體體系進行研究,但SBS改性瀝青各組分在熱氧老化和紫外老化過程中會相互影響,導致對SBS改性瀝青老化行為的深層認識仍有限。本文建立了SBS的分離方法并研究了SBS改性瀝青的紫外老化過程,以SBS改性瀝青為原料,用薄膜烘箱老化試驗方法模擬SBS改性瀝青混合料在儲運、施工、拌合過程中發生的短期老化,再采用紫外輻射試驗箱方法和自然光老化方法對SBS改性瀝青進行室內、外紫外老化試驗,對不同老化時間和老化方式的SBS改性瀝青進行外觀觀察和熒光顯微觀察,最后將四個組分和SBS改性劑分離出來,并且用紅外光譜分析各個組分隨老化時間延長的結構變化,本研究為更準確地分析出SBS改性瀝青的熱氧老化和紫外老化機理打下基礎,對評價與預測SBS改性瀝青的光氧化性能具有重要的意義。通過對以上內容的分析研究,本論文主要得到以下結論:1.設計新的SBS分離方法并證明其可行,但該方法會造成SBS的少量損失和含有部分芳香分和膠質。2.隨著老化時間延長SBS改性瀝青表面顏色由黑色向灰色轉變,有明顯的硬化收縮現象且皺紋增多增大,熒光顯微鏡分析發現SBS顆粒在基質瀝青中呈分散狀態。3.通過對不同老化時間的SBS改性瀝青進行各組分測定,可得知紫外老化后SBS改性瀝青的總體變化趨勢為飽和分、芳香分、SBS含量降低,膠質、瀝青質含量和Ic值上升。4.通過傅立葉紅外光譜分析SBS改性瀝青各組分的組成,最明顯的變化是紫外老化后羰基和亞砜基含量增加,聚丁二烯的特征峰含量降低。
[Abstract]:The exposure of SBS modified asphalt to high temperature and ultraviolet radiation will lead to thermal oxygen aging and ultraviolet aging, which will lead to the decrease of pavement performance and service life of SBS modified asphalt.It is very important to study the thermal oxygen aging and ultraviolet aging of SBS modified asphalt for improving the performance of SBS modified asphalt. At present, there have been many researches on thermal oxygen aging and ultraviolet aging of SBS modified asphalt.Most of these studies are aimed at the whole system of SBS modified asphalt, but the components of SBS modified asphalt will affect each other in the process of thermal oxygen aging and ultraviolet aging, which leads to a limited understanding of the aging behavior of SBS modified asphalt.In this paper, the separation method of SBS was established and the ultraviolet aging process of SBS modified asphalt was studied. Using SBS modified asphalt as raw material, the aging test method of membrane oven was used to simulate the storage, transportation and construction of SBS modified asphalt mixture.The short term aging occurred in the mixing process, and then the ultraviolet radiation test chamber and natural light aging method were used to carry out the indoor and external ultraviolet aging tests of SBS modified asphalt.The appearance and fluorescence microscopy of SBS modified asphalt with different aging time and aging mode were observed. Finally, four components and SBS modifier were separated out, and the structural changes of each component with aging time were analyzed by infrared spectroscopy.This study lays a foundation for more accurate analysis of thermal oxygen aging and ultraviolet aging mechanism of SBS modified asphalt, and is of great significance to evaluate and predict the photooxidation performance of SBS modified asphalt.Through the above content analysis and research, this paper mainly obtains the following conclusion: 1.A new SBS separation method was designed and proved to be feasible, but this method can cause a small loss of SBS and contain some aromatic and colloidal.With the aging time prolonging, the surface color of SBS modified asphalt changed from black to gray, and there was obvious hardening and shrinkage phenomenon, and the wrinkle increased. Fluorescence microscope analysis showed that SBS particles were dispersed in the matrix asphalt.By measuring the components of SBS modified asphalt with different aging time, it can be seen that the total change trend of SBS modified asphalt after UV aging is saturation fraction, the content of aromatic component of SBS modified asphalt decreases, the content of resin, asphaltene and IC value increase by .4.The composition of SBS modified asphalt was analyzed by Fourier transform infrared spectroscopy. The most obvious change was that the contents of carbonyl and sulfoxide increased and the characteristic peak content of polybutadiene decreased after UV aging.
【學位授予單位】：武漢工程大學
【學位級別】：碩士
【學位授予年份】：2014
【分類號】：U414

【相似文獻】

相關期刊論文 前10條

1 ;應用于高級公路的高分子改性瀝青[J];建材工業信息;2002年10期

2 李飛;周明;;改性瀝青設備技術展望[J];工程機械文摘;2003年02期

3 王元蓀;用于道路的改性瀝青材料[J];橡膠工業;2003年04期

4 李景軒,孟凡軍;改性瀝青設備的發展與應用[J];建筑機械化;2003年01期

5 張宗輝;道維施改性瀝青設備[J];建筑機械;2004年02期

6 方炬洋;改性瀝青在漳詔高速公路中的應用[J];福建建設科技;2004年04期

7 張哲,何中科;淺談改性瀝青的生產[J];山西交通科技;2005年S1期

8 李玫;;橡膠-聚乙烯改性瀝青[J];橡塑資源利用;2005年06期

9 郭強;;改性瀝青的應用及推廣[J];科學之友(學術版);2006年01期

10 楊元明;趙冰;楊璐;;改性瀝青設備的自動控制及其實現[J];中國市政工程;2006年01期

相關會議論文 前10條

1 黃婉利;俞華信;羅望群;王玲;陳定利;;改性瀝青新產品研究開發[A];新世紀 新機遇 新挑戰——知識創新和高新技術產業發展（上冊）[C];2001年

2 徐希娟;原健安;;化學改性瀝青的應用前景分析[A];中國公路學會’2001學術交流論文集[C];2001年

3 郝培文;;改性瀝青使用技術中的問題及發展趨勢[A];第五屆全國路面材料及新技術研討會論文集[C];2004年

4 楊林江;施張興;金海山;林大根;;淺談乳化改性瀝青發展方向及生產技術關鍵[A];第五屆全國路面材料及新技術研討會論文集[C];2004年

5 孔憲明;;改性瀝青的顯微觀測[A];建筑防水工程新技術第五屆學術年會論文集[C];1998年

6 ;塑性體改性瀝青、彈性體改性瀝青兩項新國標實施[A];全國第十四屆防水材料技術交流大會論文集[C];2012年

7 王燕文;陳e，

本文編號：1747174